Service ManualRoom Air ConditionersRAC-Svc-06 (3-06)2006CoolSUPER HIGH EFFICIENCYTemp/HourFan OnlyClockStartStopMoneySaver®PMVent shutExhaustFanSpeedT
10IMPORTANTANY SEALED SYSTEM REPAIRS TO COOL-ONLY MODELS REQUIRE THE INSTALLATION OF A LIQUID LINE DRIER. ALSO, ANY SEALED SYSTEM REPAIRS TO HEAT PUM
11EQUIPMENT REQUIRED 1. Voltmeter 2. Ammeter 3. Ohmmeter 4. E.P.A. Approved Refrigerant Recovery System. 5. Vacuum Pump (capable of 200 micron
12NOTE: In order to access the sealed system it will be necessary to install Schrader type fi ttings to the process tubes on the discharge and suction
13An undercharged system will result in poor performance (low pressures, etc.) in both the heating and cooling cycle.Whenever you service a unit with
14A quick check for either condition begins at the evaporator. With a partial restriction, there may be gurgling sounds at the metering device entranc
15NORMAL FUNCTION OF VALVEVALVEOPERATING CONDITIONDISCHARGE TUBE from CompressorSUCTION TUBE to CompressorTube to INSIDE COILTube to OUTSIDE COILLEFT
16COOLING ONLY ROOM AIR CONDITIONERS: TROUBLESHOOTING TIPSProblem Possible Cause ActionCompressor does not runLow voltageCheck voltage at compressor.
17Problem Possible Cause ActionUnit does not runFuse blown or circuit trippedReplace fuse, reset breaker. If repeats, check fuse or breaker size. Chec
18Problem Possible Cause ActionCompressor runs for short periods only. Cycles on overloadOverload inoperative. Opens too soonCheck operation of unit.
19Problem Possible Cause ActionWater "spitting" into roomSublimation: When unconditioned saturated, outsid
2INTRODUCTIONThis service manual is designed to be used in conjunction with the installation manuals provided with each air conditioning system compon
20HEAT / COOL ROOM AIR CONDITIONERS: TROUBLESHOOTING TIPSProblem Possible Cause ActionRoom temperature uneven (Heating cycle)Heat anticipator (resisto
21Problem Possible Cause ActionUnit cools when heat is called forIncorrect wiring Refer to applicable wiring diagramDefective solenoid coil Check for
22ELECTRICAL TROUBLESHOOTING CHART — HEAT PUMPNOIs Line VoltagePresent at the SolenoidNOYESYESTROUBLESHOOTING CHART — HEATINGNoncondensables (air)Over
23MODELSC06H10D
24MODELSXQ05L10-A,B; XQ06L10-A,B,C,D; XQ08L10-A,B; XQ10L10-A,B; XQ12L10-A,B
25MODELSKS10L10-A, RS10L10-A, KS12L10-A, KS12L30-A, KS15L10-A, RS15L10-A, RS16L30-A, RM18L30-A, KM18L30-A, KM21L30-A, RM24L30-A, KM24L30-A
26MODELSSS08L10-A/B, SS10L10-A/B, SS12L10-A/B; SS12L30-A/B, SS14L10-A/B, SS16L30-A/B, SM18L30-A/B, SM21L30-A/B, SM24L30-A/B
27MODELSL36L30-A
28MODELSL28L30-A
29MODELSSL36L30-B
3Friedrich Air Conditioning Company P.O. Box 1540San Antonio, TX 78295 210.357.4400www.friedrich.comROOM AIR CONDITIONERS LIMITED WARRANTYFIRST YEAR A
30MODELEQ08L11-A
31MODELSES12L33-A, ES16L33-A, EM18L34-A, EM24L35-A
32MODELEL36L35-A
33MODELYS09L10-A, YS09L10-B
34MODELSYS13L33-A, YM18L34-A
35MODELSYL24L35-A
RAC-Svc-06 (3-06)Friedrich Air Conditioning Co.Post Office Box 1540 • San Antonio, Texas 78295-15404200 N. Pan Am Expressway • San Antonio, Texas 7821
4ROUTINE MAINTENANCENOTE: Units are to be inspected and serviced by qualifi ed service personnel only. Inspect the indoor blower housing, evaporator
5UNIT IDENTIFICATIONModel Number Code S S 08 L 1 0 ASerial NumberDecade ManufacturedL=0 C=3 F=6 J=9 A=1 D=4 G=7B=2 E=5 H=8Year ManufacturedA=1 D=4
6PERFORMANCE DATAModelEVAPORATORAIR TEMP °FCONDENSER TEMP °FDISCHARGE TEMPSUCTION TEMPSUPER HEATSUB-COOLINGOPERATING PRESSURESELECTRICAL RATINGSR-22
7Wire Size Use ONLY wiring size recommended for single outlet branch circuit.Fuse/Circuit Use ONLY type and size fuse or HACR Breaker circuit break
8MECHANICAL COMPONENTSBellows condensate valve Temperature-sensitive valve that opens up to drain off condensate water when the outside temperature f
9ELECTRONIC CONTROLSIMPORTANT: Error Codes are cleared from the log by exiting from Error Code Mode. To exit on XQ models, press Timer On/Off button.
Comments to this Manuals